Chinaunix

标题: SE3510控制器怪象 [打印本页]

作者: oldhero 时间: 2012-10-29 16:47
标题: SE3510控制器怪象
SE3510双控，其中一个控制器亮黄灯，无法识别了。
在更换了故障控制器后，控制器指示灯为绿色，但通过SCCLI查看show fru状态显示仍为Failed，show redun 显示一直为scaaning状态。
将新换的控制器重新拔插，重启阵列，更换控制器位置，升级Frimware后，将新换控制器恢复出厂设置后仍然是一样的状态。
又拿一个控制器重新更换还是一样的。
通过串口连接到新换上的控制器可以正常操作控制器，通过SCCLI也可以也可以升级控制器Frimware，通过串口查看新换的控制器只把IP地址同步过去了，Frimware版本也跟原来的控制器一致。能识别到LUN，硬盘，但没有mapping信息。
单独使用新换的控制器启动阵列也不正常，Restore nvarm from disk时也报错，不能Restore。

不知道什么原因两个控制器之间不能正常同步了。请大家帮忙看看。

Sun StorEdge 3000 Family CLI
Copyright 2002-2007 Dot Hill Systems Corporation.
All rights reserved. Use is subject to license terms.
sccli version 2.4.0
built 2007.07.04.17.54
build 22 for solaris-sparc

* inquiry-data

Vendor: SUN
Product: StorEdge 3510
Revision: 423A
Peripheral Device Type: 0x0
NVRAM Defaults: 423A 3510 S491F
Bootrecord version: 1.31H
Serial Number: 085815
Page 80 Serial Number: 08581534E6996800
Page 83 Logical Unit Device ID: 600C0FF00000000008581534E6996800
Page 83 Target Device ID: 206000C0FF085815
IP Address: 192.168.106.10
Page D0 Fibre Channel Address: 9B (id 47)
Page D0 Node Name: 206000C0FF085815
Page D0 Port Name: 266000C0FFF85815
Ethernet Address: 00:C0:FF:08:58:15
Device Type: Primary
unique-identifier: 85815
controller-name: ""

* network-parameters

ip-address: 192.168.106.10
netmask: 255.255.255.0
gateway: 0.0.0.0
mode: static

* host-parameters

max-luns-per-id: 32
queue-depth: 1024
fibre-connection-mode: loop
inband-management: enabled

* drive-parameters

spin-up: disabled
disk-access-delay: 15s
scsi-io-timeout: 30s
queue-depth: 32
polling-interval: 30s
enclosure-polling-interval: 30s
auto-detect-swap-interval: disabled
smart: detect-only
auto-global-spare: disabled

* redundant-controller-configuration

  Redundant Controller Configuration:       primary
  Cache Synchronization:                   enabled
  Host Channel Failover Mode:                shared
  Local/Remote Redundant Mode:             local
  Write-Through Data Synchronization:       enabled
  Secondary RS-232 Port Status:             disabled
  Communication Channel Type:                Fibre

* redundancy-mode

Primary controller serial number: 8059727
Primary controller location: Upper
Redundancy mode: Active-Active
Redundancy status: Scanning
Secondary controller serial number: 0

* cache-parameters

mode: write-back
optimization: sequential
sync-period: disabled
current-global-write-policy: write-through

* RS232-configuration

COM1 speed: 38400bps

* channels

Ch  Type Media Speed Width  PID / SID
--------------------------------------------
0  Host FC(L) 2G    Serial  40 / N/A
1  Host FC(L) 2G    Serial  43 / N/A
2  DRV+RCC FC(L) 2G    Serial  14 / 15
3  DRV+RCC FC(L) 2G    Serial  14 / 15
4  Host FC(L) 2G    Serial  44 / N/A
5  Host FC(L) 2G    Serial  47 / N/A
6  Host LAN    N/A    Serial  N/A / N/A

* disks

Ch    Id    Size Speed  LD    Status    IDs                   Rev
----------------------------------------------------------------------------
2    0  279.40GB 200MB  ld0 ONLINE    SEAGATE ST330000FSUN300G 055A
                                                S/N 0653L0S3
                                                WWNN 20000024B61E9547
2    1  279.40GB 200MB  ld0 ONLINE    SEAGATE ST330000FSUN300G 055A
                                                S/N 2050J6EG
                                                WWNN 20000024B61FFD3B
2    2  279.40GB 200MB  GLOBAL STAND-BY SEAGATE ST330000FSUN300G 055A
                                                S/N 0253GNP9
                                                WWNN 20000018627B59E4
2    3  279.40GB 200MB  ld0 ONLINE    SEAGATE ST330000FSUN300G 055A
                                                S/N 1051S8MR
                                                WWNN 20000024B61F374D
2    4  279.40GB 200MB  ld0 ONLINE    SEAGATE ST330000FSUN300G 055A
                                                S/N 1651XXSW
                                                WWNN 20000024B61F3CE1
2    5  279.40GB 200MB  GLOBAL STAND-BY SEAGATE ST330000FSUN300G 055A
                                                S/N 30549EE7
                                                WWNN 2000001862D4ECF5
2    6  279.40GB 200MB  ld1 ONLINE    SEAGATE ST330000FSUN300G 055A
                                                S/N 2150HPKE
                                                WWNN 20000024B61FFD6E
2    7  279.40GB 200MB  ld1 ONLINE    SEAGATE ST330000FSUN300G 055A
                                                S/N 5151ADK7
                                                WWNN 20000024B61F0413
2    8  279.40GB 200MB  ld1 ONLINE    SEAGATE ST330000FSUN300G 055A
                                                S/N 18540Y9F
                                                WWNN 20000024B61F21BD
2    9  279.40GB 200MB  ld1 ONLINE    SEAGATE ST330000FSUN300G 055A
                                                S/N 26543680
                                                WWNN 20000024B61F3D37
2    10  279.40GB 200MB  ld1 ONLINE    SEAGATE ST330000FSUN300G 055A
                                                S/N 2050JDT8
                                                WWNN 20000024B61FFD58
2    11  279.40GB 200MB  ld0 ONLINE    SEAGATE ST330000FSUN300G 055A
                                                S/N 0351GXS6
                                                WWNN 20000024B61F057B

* logical-drives

LD LD-ID       Size  Assigned  Type Disks Spare  Failed Status
------------------------------------------------------------------------
ld0 34E69968 1.09TB  Primary RAID5  5    2    0    Good
                     Write-Policy Default       StripeSize 128KB
ld1 74401D24 1.09TB  Primary RAID5  5    2    0    Good
                     Write-Policy Default       StripeSize 128KB

* logical-volumes

* partitions

LD/LV ID-Partition       Size
-------------------------------------
ld0-00 34E69968-00    1.00GB
ld0-01 34E69968-01    1.10GB
ld0-02 34E69968-02    488.28GB
ld0-03 34E69968-03    626.21GB
ld1-00 74401D24-00    1.00GB
ld1-01 74401D24-01    1.10GB
ld1-02 74401D24-02    488.28GB
ld1-03 74401D24-03    626.21GB

* lun-maps

Ch Tgt LUN ld/lv ID-Partition  Assigned  Filter Map
---------------------------------------------------------------------
0  40 0 ld0    34E69968-00 Primary
0  40 1 ld0    34E69968-01 Primary
0  40 2 ld0    34E69968-02 Primary
0  40 3 ld0    34E69968-03 Primary
0  40 4 ld1    74401D24-00 Primary
0  40 5 ld1    74401D24-01 Primary
0  40 6 ld1    74401D24-02 Primary
0  40 7 ld1    74401D24-03 Primary
1  43 0 ld0    34E69968-00 Primary
1  43 1 ld0    34E69968-01 Primary
1  43 2 ld0    34E69968-02 Primary
1  43 3 ld0    34E69968-03 Primary
1  43 4 ld1    74401D24-00 Primary
1  43 5 ld1    74401D24-01 Primary
1  43 6 ld1    74401D24-02 Primary
1  43 7 ld1    74401D24-03 Primary
4  44 0 ld0    34E69968-00 Primary
4  44 1 ld0    34E69968-01 Primary
4  44 2 ld0    34E69968-02 Primary
4  44 3 ld0    34E69968-03 Primary
4  44 4 ld1    74401D24-00 Primary
4  44 5 ld1    74401D24-01 Primary
4  44 6 ld1    74401D24-02 Primary
4  44 7 ld1    74401D24-03 Primary
5  47 0 ld0    34E69968-00 Primary
5  47 1 ld0    34E69968-01 Primary
5  47 2 ld0    34E69968-02 Primary
5  47 3 ld0    34E69968-03 Primary
5  47 4 ld1    74401D24-00 Primary
5  47 5 ld1    74401D24-01 Primary
5  47 6 ld1    74401D24-02 Primary
5  47 7 ld1    74401D24-03 Primary

* protocol

Identifier    Status    Port  Parameters
--------------------------------------
telnet       enabled 23 inactivity-timeout=disabled
http          enabled 80 n/a
https          disabled  n/a n/a
ftp          enabled 21 n/a
ssh          disabled  n/a n/a
priagent       enabled 58632 n/a
snmp          disabled  n/a n/a
dhcp          enabled 68 n/a
ping          enabled n/a n/a

* auto-write-through-trigger

controller-failure: enabled
battery-backup-failure: enabled
ups-ac-power-loss: disabled
power-supply-failure: enabled
fan-failure: enabled
temperature-exceeded-delay: 30min

* peripheral-device-status

Item                               Value    status
-------------------------------------------------------------
CPU Temp Sensor(primary)          44.50C within safety range
Board1 Temp Sensor(primary)       48.00C within safety range
Board2 Temp Sensor(primary)       54.00C within safety range
+3.3V Value(primary)             3.416V within safety range
+5V Value(primary)                5.126V within safety range
+12V Value(primary)                12.442V within safety range
Battery-Backup Battery(primary)    06       Hardware:Charging
CPU Temp Sensor(secondary)       N/A    N/A
Board1 Temp Sensor(secondary)    N/A    N/A
Board2 Temp Sensor(secondary)    N/A    N/A
+3.3V Value(secondary)             N/A    N/A
+5V Value(secondary)             N/A    N/A
+12V Value(secondary)             N/A    N/A
Battery-Backup Battery(secondary) --       Hardware:N/A

* enclosure-status

Ch  Id Chassis Vendor/Product ID Rev  PLD  WWNN          WWPN
-------------------------------------------------------------------------------
2  12 085815  SUN StorEdge 3510F A 1106 1000 204000C0FF085815 214000C0FF085815
                                    Topology: loop(a)  Status:    OK
3  12 085815  SUN StorEdge 3510F A 1106 1000 204000C0FF085815 224000C0FF085815
                                    Topology: loop(b)  Status:    OK

Enclosure Component Status:
   Type Unit Status FRU P/N FRU S/N Add'l Data
------------------------------------------------------------------
   Fan 0 OK    370-6776  GM1FXJ    --
   Fan 1 OK    370-6776  GM1FXJ    --
   Fan 2 OK    370-6776  GM0V89    --
   Fan 3 OK    370-6776  GM0V89    --
   PS 0 OK    370-6776  GM1FXJ    --
   PS 1 OK    370-6776  GM0V89    --
   Temp 0 OK    370-5535  085815    temp=22
   Temp 1 OK    370-5535  085815    temp=20
   Temp 2 OK    370-5535  085815    temp=21
   Temp 3 OK    370-5535  085815    temp=21
   Temp 4 OK    370-5535  085815    temp=22
   Temp 5 OK    370-5535  085815    temp=20
   Temp 6 OK    370-5537  HH18DF    temp=28
   Temp 7 OK    370-5537  HH18DF    temp=27
   Temp 8 OK    371-0532  HL15RF    temp=25
   Temp 9 OK    371-0532  HL15RF    temp=28
   Temp 10 OK    370-6776  GM1FXJ    temp=30
   Temp 11 OK    370-6776  GM0V89    temp=26
  Voltage 0 OK    370-6776  GM1FXJ    voltage=5.280V
  Voltage 1 OK    370-6776  GM1FXJ    voltage=12.160V
  Voltage 2 OK    370-6776  GM0V89    voltage=5.230V
  Voltage 3 OK    370-6776  GM0V89    voltage=11.940V
  Voltage 4 OK    370-5537  HH18DF    voltage=2.510V
  Voltage 5 OK    370-5537  HH18DF    voltage=3.300V
  Voltage 6 OK    370-5537  HH18DF    voltage=5.050V
  Voltage 7 OK    370-5537  HH18DF    voltage=12.240V
  Voltage 8 OK    371-0532  HL15RF    voltage=2.500V
  Voltage 9 OK    371-0532  HL15RF    voltage=3.290V
  Voltage 10 OK    371-0532  HL15RF    voltage=5.050V
  Voltage 11 OK    371-0532  HL15RF    voltage=12.240V
DiskSlot 0 OK    370-5535  085815    addr=0,led=off
DiskSlot 1 OK    370-5535  085815    addr=1,led=off
DiskSlot 2 OK    370-5535  085815    addr=2,led=off
DiskSlot 3 OK    370-5535  085815    addr=3,led=off
DiskSlot 4 OK    370-5535  085815    addr=4,led=off
DiskSlot 5 OK    370-5535  085815    addr=5,led=off
DiskSlot 6 OK    370-5535  085815    addr=6,led=off
DiskSlot 7 OK    370-5535  085815    addr=7,led=off
DiskSlot 8 OK    370-5535  085815    addr=8,led=off
DiskSlot 9 OK    370-5535  085815    addr=9,led=off
DiskSlot 10 OK    370-5535  085815    addr=10,led=off
DiskSlot 11 OK    370-5535  085815    addr=11,led=off

* SES

Ch  Id Chassis Vendor/Product ID       Rev  PLD  WWNN          WWPN
-------------------------------------------------------------------------------
2  12 085815  SUN StorEdge 3510F A    1106 1000 204000C0FF085815 214000C0FF085815
                                                   Topology: loop(a)
3  12 085815  SUN StorEdge 3510F A    1106 1000 204000C0FF085815 224000C0FF085815
                                                   Topology: loop(b)

* port-WWNs

Ch  Id WWPN
-------------------------
0  40 216000C0FF885815
1  43 226000C0FFB85815
4  44 256000C0FFC85815
5  47 266000C0FFF85815

* inter-controller-link

inter-controller-link upper channel 0: connected
inter-controller-link lower channel 0: connected
inter-controller-link upper channel 1: connected
inter-controller-link lower channel 1: connected
inter-controller-link upper channel 4: connected
inter-controller-link lower channel 4: connected
inter-controller-link upper channel 5: connected
inter-controller-link lower channel 5: connected

* battery-status

Upper Battery Type: 1
Upper Battery Manufacturing Date: Tue Apr  6 00:00:00 2010
Upper Battery Placed In Service:  Tue Jan  4 05:14:26 2011
Upper Battery Expiration Date: Thu Jan  3 17:14:26 2013
Upper Battery Expiration Status:  OK

Lower Battery Type: 1
Lower Battery Manufacturing Date: Fri Aug 18 00:00:00 2006
Lower Battery Placed In Service:  Tue Oct 24 12:23:41 2006
Lower Battery Expiration Date: Fri Oct 24 00:23:41 2008
Lower Battery Expiration Status:  Expired

---------------------------------------------------------------
Upper Battery Hardware Status: Charging
Lower Battery Hardware Status: N/A

* sata-router

no sata routers found

* sata-mux

0 mux boards found

* host-wwn-names

* FRUs

7 FRUs found in chassis SN#085815 at ch 2 id 12

Name: FC_CHASSIS_BKPLN
Description: SE3510 FC Chassis/backplane
Part Number: 370-5535
Serial Number: 085815
Revision: 02
Initial Hardware Dash Level: 02
FRU Shortname: 370-5535-02
Manufacturing Date: Sun Jan 16 19:01:10 2005
Manufacturing Location: Penang,Malaysia
Manufacturer JEDEC ID: 0x0301
FRU Location: FC MIDPLANE SLOT
Chassis Serial Number: 085815
FRU Status: OK

Name: FC_RAID_IOM
Description: SE3510 I/O w/SES RAID FC 2U
Part Number: 370-5537
Serial Number: HH18DF
Revision: 08
Initial Hardware Dash Level: 08
FRU Shortname:
Manufacturing Date: Mon Apr  3 12:56:52 2006
Manufacturing Location: Suzhou,China
Manufacturer JEDEC ID: 0x0301
FRU Location: UPPER FC RAID IOM SLOT
Chassis Serial Number: 085815
FRU Status: OK

Name: BATTERY_BOARD
Description: SE351X Hot Swap Battery Module
Part Number: 371-0539
Serial Number: GP002M
Revision: 01
Initial Hardware Dash Level: 01
FRU Shortname:
Manufacturing Date: Tue Sep  1 01:17:31 2009
Manufacturing Location: Suzhou,China
Manufacturer JEDEC ID: 0x0301
FRU Location: UPPER BATTERY BOARD SLOT
Chassis Serial Number: 085815
FRU Status: OK

Name: AC_POWER_SUPPLY
Description: AC PWR SPLY FAN MOD 2U FC/SATA
Part Number: 370-6776
Serial Number: GM0V89
Revision: 01
Initial Hardware Dash Level: 01
FRU Shortname: FC/SATA AC PS
Manufacturing Date: Fri Oct 22 05:23:03 2004
Manufacturing Location: Irvine California, USA
Manufacturer JEDEC ID: 0x048F
FRU Location: RIGHT AC PSU SLOT #1 (RIGHT)
Chassis Serial Number: 085815
FRU Status: OK

Name: AC_POWER_SUPPLY
Description: AC PWR SPLY FAN MOD 2U FC/SATA
Part Number: 370-6776
Serial Number: GM1FXJ
Revision: 01
Initial Hardware Dash Level: 01
FRU Shortname: FC/SATA AC PS
Manufacturing Date: Wed Feb  9 12:21:30 2005
Manufacturing Location: Irvine California, USA
Manufacturer JEDEC ID: 0x048F
FRU Location: AC PSU SLOT #0 (LEFT)
Chassis Serial Number: 085815
FRU Status: OK

Name: FC_RAID_IOM
Description: SE3510 I/O w/SES RAID FC 2U
Part Number: 371-0532
Serial Number: HL15RF
Revision: 01
Initial Hardware Dash Level: 01
FRU Shortname:
Manufacturing Date: Tue Oct 31 23:10:50 2006
Manufacturing Location: Suzhou,China
Manufacturer JEDEC ID: 0x0301
FRU Location: LOWER FC RAID IOM SLOT
Chassis Serial Number: 085815
FRU Status: Fault

Name: BATTERY_BOARD
Description: SE351X Hot Swap Battery Module
Part Number: 371-0539
Serial Number: GP1860
Revision: 01
Initial Hardware Dash Level: 01
FRU Shortname:
Manufacturing Date: Wed Sep 13 03:04:54 2006
Manufacturing Location: Suzhou,China
Manufacturer JEDEC ID: 0x0301
FRU Location: LOWER BATTERY BOARD SLOT
Chassis Serial Number: 085815
FRU Status: Expired

* access-mode

access-mode: inband

* controller-date

Boot time : Mon Oct  5 16:51:48 2009
Current time : Mon Oct  5 17:31:42 2009
Time Zone : GMT -05:15

* disk-array

init-verify: disabled
rebuild-verify: disabled
normal-verify: disabled
rebuild-priority: low

作者: 119beyond 时间: 2012-10-30 14:31
Name: FC_RAID_IOM
Description: SE3510 I/O w/SES RAID FC 2U
Part Number: 371-0532
Serial Number: HL15RF
Revision: 01
Initial Hardware Dash Level: 01
FRU Shortname:
Manufacturing Date: Tue Oct 31 23:10:50 2006
Manufacturing Location: Suzhou,China
Manufacturer JEDEC ID: 0x0301
FRU Location: LOWER FC RAID IOM SLOT
Chassis Serial Number: 085815
FRU Status: Fault

Name: BATTERY_BOARD
Description: SE351X Hot Swap Battery Module
Part Number: 371-0539
Serial Number: GP1860
Revision: 01
Initial Hardware Dash Level: 01
FRU Shortname:
Manufacturing Date: Wed Sep 13 03:04:54 2006
Manufacturing Location: Suzhou,China
Manufacturer JEDEC ID: 0x0301
FRU Location: LOWER BATTERY BOARD SLOT
Chassis Serial Number: 085815
FRU Status: Expired

作者: yulemi 时间: 2012-10-30 22:49
再换个控制器试试

作者: oldhero 时间: 2012-10-31 13:31
这是换的第三个控制器了。
现象还是一样的。

作者: KYOKOF 时间: 2012-11-01 09:05
你等了多长时间啊双控冗余配置的控制器在线更换故障控制器好像要等控制器的同步的好像要15分钟吧

作者: oldhero 时间: 2012-11-01 15:04
换上去后，我直在观察设备的状态了，一开始还是显示正常的，过一会就变成FAULT了。
我重新拨插控制器起码等了半个小时。

作者: wait空白 时间: 2012-11-01 16:01
强制恢复失效控制器有试过没？

作者: oldhero 时间: 2012-11-02 17:45
是reset nvarm吗？
在新换上去的控制器试过
由于有数据在原来好的控制器没有试过。

顺便问下，3510里面有没有强制清空NVARM的操作？

作者: oldhero 时间: 2012-11-05 13:10
3510里面有没有强制清空NVARM的操作？

作者: znnnz 时间: 2012-11-06 12:38
再换控制器前要先看原控制器的固件版本，假如是4.xx，而你换上的新控制器是3.xx，是不能自动同步的，也是不能直接用sccli来升级的。

作者: oldhero 时间: 2012-11-08 14:42
那是不是需要将新控制器先在其它3510上将Firmaware升级到4.xx再换上去

作者: 119beyond 时间: 2012-11-29 16:09
等待下文的

欢迎光临 Chinaunix (http://bbs.chinaunix.net/)